前沿拓展：

哈雷摩托車在使用過程中難免會有各種各樣的問題.

比如有時儀表上顯示"NO FOB"而無法啟動摩托車,這時候要檢查感應鑰匙是否在身上,是否內置的紐扣電池電量不足.感應鑰匙內部電池(一枚CR2032紐扣電池)一般可工作3年,更換也較簡單,先網購型號"CR2032"紐扣電池.兩三塊錢一枚.用一字螺絲刀或類似硬物撬開感應鑰匙更換就可以了.主要正負極不要反了.

再比如儀表上突然亮起了紅色小燈提示,有時是持續的也有可能偶發的提示.這意味著車輛電器設備可能出現了問題,比如大燈異常,轉向燈異常,剎車燈異常燈.如果是更換了山寨LED大燈導致偶發紅色小燈提示,也不用過分擔心,它不會導致不良后果,只是山寨的LED大燈功率不達標,車輛BCM模塊認為燈出現了故障進行的提示而已.

有些時候發動機故障燈會亮起,那么這個時候就要注意了,無論是持續故障還是偶發故障,都要進行必要的查看,獲得出故障的位置,并加以處理.也有的時候,某些故障會導致記錄故障碼,但是不會促使發動機故障燈亮起,也可以通過故障碼的查詢來判斷車況是否正常.

哈雷摩托車自身提供了查詢和清除故障碼的功能,從儀表液晶屏顯示.要查詢發動機故障碼,需要找到"TRIP"鍵.年份不同,這個TRIP按鈕位置不同,老款哈雷一般會在儀表的背后,新款的一般在車把手左側按鈕中,通過這個按鈕可以切換儀表的各類型(檔顯,轉速,總里程,時間等)切換.如圖箭頭所指:

按住TRIP按鈕不放,擰開鑰匙門或者按下總開關:

這時候注意看儀表盤的液晶屏,如下所示即可松開TRIP按鍵:

液晶屏顯示diag,是"診斷"的英文.這時候仍舊主要使用TRIP鍵,分短按和長按,可以把短按理解為鼠標點擊或者選擇,把長按理解為確定鍵.

短按一次TRIP鍵后,可以看到PSSPT這樣.分別對應系統中不同部件類型,如下表:

短按TRIP鍵,切換標志符,字母閃爍代表當前選擇,再次長按TRIP鍵可進入當前選擇所選分類下查看是否有故障碼,如顯示NONE字樣.則代表當前分類中無故障碼:

如顯示 no rsp字樣,則代表車沒有配備這個模塊,如在選ECM模塊時看到該提示,說明開關沒有打開"總開關".

如果有故障碼,則會顯示如P1234字樣,短按TRIP鍵可看下一個故障碼,如無下一個故障碼,則顯示END字樣.如果發現有故障碼,建議拍照或者用筆記錄故障碼,以便查詢故障碼含義.當顯示故障碼時,長按TRIP鍵則會清除故障碼.

成功清除故障碼,將顯示CLEAR字樣:

清除故障碼不代表故障被清除,但是有的故障是偶發的,有的是持續的,清除故障碼后運轉發動機騎行后再次查詢,如果故障碼再次出現,則說明該故障持續存在,如故障碼不再出現,則說明故障為偶發,需留意觀察.

要退出診斷模式,只需關閉鑰匙門或者關閉總開關即可.查到故障碼后,便可通過故障碼搜尋到對應的故障含義,哈雷故障碼與機動車故障碼相同標準,大多數都能網上搜尋得到結果.比如用"故障碼 P1234"為關鍵字搜索即可看到結果.

故障碼查詢表如下:

1. P0605 ECM FLASH Memory Error

2. P0603 ECMEEPROMMemoryError

3. U1300 ECM Serial Data Low

4. U1301 ECM Serial Data High

5. U1097 Loss of Speedometer Serial Data to ECM

6. U1064 Loss of TSM/FSFM Serial Data to ECM

7. P1003 System relay contacts open

8. P1002 System Relay Coil High/Shorted

9. P1001 System Relay Coil Open/Low

10. P1004 System Relay Contacts Closed

11. P1009 Incorrect Password

12. P1010 Missing Password

13. P06415 V+Vref 1 Out Of Range

14. P06515 V+Vref 2 Out Of Range

15. P0373 CKP Sensor Intermittent

16. P0107 Map Sensor Open/Low

17. P0108 Map Sensor High

18. P0374 CKP Sensor Synch Error

19. P1600 EFI Module Processor Internal Error

20. P1270 TGS Validation Error

21. P2107 EFI Module Processor Internal Fault

22. P2122 TGS1 Low/Open

23. P2123 TGS1 High

24. P2127 TGS2 Low/Open

25. P2128 TGS2 High

26. P2138 TGS Correlation Error (Twist grip sensor)

27. P0120 TPS1 Range Error

28. P0220 TPS2 Range Error

29. P0122 TPS1 Low

30. P0123 TPS2 High/Open

31. P0222 TPS2 Low

32. P0223 TPS2 High/Open

33. P2135 TPS Correlation Error

34. P2119 EFI Motor Throttle Body Range Performance

35. P2100 EFI Motor Circuit Open

36. P2101 EFI Motor Circuit Range Performance (Actuation Error)

37. P2102 EFI Motor Circuit Low

38. P2103 EFI Motor Circuit High

39. P2176 EFI Closed Position Not Learned

40. P1514 Air Flow Fault

41. P2105 EFI Forced engine shutdown

42. P1501 Jiffy Stand Sensor Low

43. P1502 Jiffy Stand Sensor High

44. P0572 Brake Switch Low

45. P0117 ET Sensor Low

46. P0118 ET Sensor High

47. P0112I AT Voltage Low

48. P0113I AT Voltage Open/High

49. P1351 Front Ignition Coil Driver Open/Low

50. P1354 Rear Ignition Coil Driver Open/Low

51. P1352 Front Ignition Coil Driver High/Shorted

52. P1355 Rear Ignition Coil Driver High/Shorted

53. P1357 Front Cylinder Combustion Intermittent

54. P1358 Rear Cylinder Combustion Intermittent

55. P0261 Front Injector Open/Low

56. P0263 Rear Injector Open/Low

57. P0262 Front Injector High

58. P0264 Rear Injector High

59. P0562 Battery Voltage Low

60. P0563 Battery Voltage High

61. P0501 VSS Sensor Low

62. P0502 VSS Sensor High/Open..

63. P1356 Rear Cylinder No Combustion

64. P1353 Front Cylnder No Combustion

65. P0444 Purge Solenoid Open/Low

66. P0445 Purge Solenoid High

67. P1475 Exhaust Actuation Position Error

68. P1477 Exhaust Actuator Open/Low

69. P1478 Exhaust Actuator Shorted/High

70. P0131 Front Oxygen Sensor Low

71. P0151 Rear Oxygen Sensor Low

72. P0132 Front Oxygen Sensor High

73. P0152 Rear Oxygen Sensor High

74. P0134 Front Oxygen Sensor Inactive

75. P0154 Rear Oxygen Sensor Inactive

76. P1510 EFI Limited Performance Mode

77. P1511 EFI Power Management Mode

78. P1512 EFI Forced Idle Mode

79. P0577 Cruise Control Input High

80.. U1300 Serial Data Low

81. U1301 Serial Data High

82. U1016 Loss of ECM Serial Data

83. U1255 Serial Data Error

84. B1142 Smart Security System Internal Fault

85. B1135 Accelerometer Failed

86. B1136(HFSM) Accelerometer Tip Test Error

87. B1151 Bank Angle Sensor(BAS) Short to Ground

88. B1152 Bank Angle Sensor(BAS) Short to Battery

89. B1153 Bank Angle Sensor(BAS) High

90. B1154 Clutch Switch Input Short to Ground

91. B1155 Neutral Switch Input Short to Battery

92. B1134 Starter Output High

93. B1121(TSM) Left Turn Output Fault. or (HFSM) Left Turn Output Open

94. B1122(TSM) Right Turn Output Fault. or (HFSM) Right Turn Output Open

95. B1123(HFSM) Left Turn Output Short to Ground

96. B1124(HFSM) Right Turn Output Short to Ground

97. B1125(HFSM) Left Turn Output Short to Battery

98. B1126(HFSM) Right Turn Output Short to Battery

99. B1143(HFSM) Security Antenna Short to Ground

100. B1144(HFSM) Security Antenna Short to Battery

101. B1145(HFSM) Security Antenna Open

102. B0563 Battery Voltage High

103. B1131(HFSM) Alarm Output Low

104. B1132(HFSM) Alarm Output High

105. B1141 Ignition Switch Low/Open.

好,關于故障碼就寫到這里,歡迎留言,歡迎關注,

拓展知識：